Leathercraft by OHD Catalog 2024

116 R e c h a r g e a b l e B a t t e r y P a c k f o r R e c l i n e r TROUBLESHOOTING GUIDE Problem: No Power Output from Battery Pack Battery not Holding a Charge LED Indicator Light Does Not Light Up When Plugged into Wall Outlet Check the connection between the battery pack and the recline motor and check Battery status by pressing the Test button on side of unit. The number of recline cycles the battery can execute depends on the size of the occupant and the number of accessories connected to the system such as LED lighting or USB chargers. Confirm the AC cord is properly connected to the wall outlet and battery pack. NO LED On: plug the battery pack into an outlet to-recharge. Wait 30 second and the RED LED will illuminate indicating it is charging. Allow 5 hours to fully charge the battery pack. It may be beneficial to disconnect the battery pack from the furniture during the charging process. Confirm outlet used for charging is working properly. RED LED: this indicates the battery needs to be charged. A fully charged battery pack should provide over 200 uses, dependent on load and accessories. The battery pack will discharge when idle. Verify circuit breakers in the house are not tripped. GREEN LED: indicates battery is fully charged and ready for use. If the battery pack does not hold a charge as indicated then contact customer service at (888)987-1011 or customerservice@raffel. com. If the battery pack does not recharge as indicated then contact customer service at (888)987-1011 or customerservice@ raffel.com. OPERATING INSTRUCTIONS 1. Be sure the battery is fully charged before use. To confirm this, press the Test button on the side of the unit. If the indicator light is green then the battery is ready for use. If the indicator light is red, plug it into an outlet to charge. 2. To install, connect the cord with the female connector to the male 2-pin plug hard wired to the recline motor. Be sure to position the battery pack in a location where the cord will not be damaged in the recline mechanism. 3. Press the test button on the side of the battery pack to check the status of the battery while in use. If the battery has enough power to properly operate the furniture the test button will activate a GREEN LED. When the battery drops to 20% capacity, the test button will activate a RED LED. When this occurs, plug the battery pack into a standard wall outlet to recharge. 4. During the charging process a LED light will constantly indicate the current status of the battery pack. A RED LED indicates the charging process is not complete. A GREEN LED indicates the battery is fully charged. *You have the option of using the battery while it is charging but this will require a much longer charging time before the battery is fully charged. **Do not completely drain the battery as this may reduce the life of the battery. ***Once the battery is fully charged, unplug it from the wall outlet. Leaving the battery plugged into a wall outlet while fully charged will cause the battery to drain more quickly during use. Notes: 1. Do not dispose of electrical appliance as unsorted municipal waste, use proper collection facilities. 2. Contact your local government for information regarding the collection system available. 3. Use only a power supply cord, Type SPT-1, 22awg, two conductors, rated minimum 105°C, 300V, VW-1. One end terminates in an attachment AC plug of 15A, 125V (NEMA 1-15P) or 15A, 250V (NEMA 2-15P), the other end terminates in a molded-on connector which mates with the Power appliance inlet. Minimum 2.3m in length. FEATURES • Provides power for up to 275 uses on a single charge dependent on configuration • y to use LED charging indicator • 5 hour charging time with integrated switching power supply • m Requirements: 100Vac-240Vac, 50/60Hz • e installation • d and engineered in the USA • d States based parts and technical support • L Listed • 1 year warranty WARNINGS 1. Keep away from flammable material and heat sources. 2. For indoor use only. 3. Dry location only. 4. Do not short circuit the battery, over charge or over discharge. 5. Do not allow the battery pack to become crushed. 6. Do not drop the battery into water. 7. Do not reverse the polarity. 8. Do not disassemble or repair the battery. 9. Do not install near metallic parts that could cause a short circuit. 10.Do not deform the battery housing. 11. Do not touch a leaky battery. 12. Do not use this battery with other devices it is not intended for. 13. Keep out of the reach of children. ONE YEAR LIMITEDWARRANTY LED Charge Indicator 146 *See Price Book for Standard Features RECHARGAB L E BAT T ERY PACK FOR REC L I NER